Quote Originally Posted by wiggy View Post
I want to tell everyone here what I experienced in the last week to give a heads up on what could happen if all the bad scenarios work out.

I was backing my bike out of the garage the other morning and thought "Dang, this beast isn't backing up too well. I got off the bike and noticed the rear tire seemed very low. I had just checked it a couple days prior and it was ok. My tire gauge registered a whopping 7psi.

I put the bike up on the center stand and started spinning the tire while spraying with dish soap solution. I found the culprit.


I had about 7600 miles on the back tire and it appeared to have a few thou left on it. I've been successful in the past with putting a StopNGo style mushroom plug in a couple tires.
For those not familiar, with this kit, a tire can be plugged right on the bike. Here is a pic of the kit and the mushroom plugs, which get shot through the tire and then pulled to seat the head against the inside of the tire.


On Saturday, I checked the pressure in the morning before taking off for the Illinois Freedom Run with a couple Vet buddies. It was down to about 37psi from the 41 I aired it up to a couple days earlier. I added air once again to get the bike up to 43psi.
The ride was uneventful until coming home. I noticed the B just started to get a little less responsive. Since I was in staggered formation, I weaved a couple times and didn't like how it was responding. The B even started to smell like a brake pad was dragging. I pulled off into a gas station, dismounted and notice the back tire was VERY low again and was the reason for the poor handling.

Upon rolling the bike over to the Air Station, I noticed my previous plug was nowhere to be seen and the reason for the air loss. I also noticed the tire was pretty hot. I at this point was just thinking about getting the bike home without anything major happening. I had the plug kit on me and decided to put another plug in, which I did. I then aired the tire up, checking the pressure as I went. I was laying on the ground to get under the saddlebag and have access to the tire valve.

As soon as I saw 41psi, I stopped airing up. No more than a couple seconds later, I heard what sounded like a shotgun blast and felt a big thud on my chest. The sidewall let go right in front of me and I got the whole blast of escaping air. I was wearing safety glasses but my face also got pelted with rubber bits and pieces.





This is what shot out into my face and chest.


I'm very lucky the sidewall gave out when it did instead of 10 minutes later when I might have been doing 50. One reason I bring this up is because I just saw a thread where a few members were advising another member to plug his tire and ride it. I myself will only plug in an emergency situation from now on---to get a bike home. Then I'll take it to a tire place to get a stinger style patch put in from the inside.

I realize the sidewall let go because of the heat buildup from the low pressure of the tire as the plug gave way and air escaped...but WOW. Talk about a "Hold my beer and Watch this moment!?"
So, Are you going to plug or patch that?
Just kidding, glad you are safe. But I see a new tire in your future.